6G Celicas Forums

Welcome Guest ( Log In | Register )

 
Reply to this topicStart new topic
> Hot Stalling problem SOLVED 2.2 liter 5S-FE Bad Caps in ECU, stalling at stop lights, stalling after warmup
post Sep 14, 2020 - 9:36 AM
+Quote Post
71Bacon

Enthusiast

Joined Sep 14, '20
From 95Celica
Currently Offline

Reputation: 0 (0%)




Hello out there in ancient Toyota-land,

So, I've spent 6 months or so chasing an idling / stalling problem with my 1995 Celica GT, US domestic market 2.2 liter 5S-FE

The symptoms were the car would stall when warmed up and then would not restart until after it had cooled off. I checked it and it had absolutely no spark at all. Following the diagnosis procedure in the factory maintenance manual led to either "bad wiring harness" or "Bad ECU". In addition a repair shop and even the dealer took a crack at it and the only error the dealer could come up with was "faulty signal from distributor" or something like that. The ECU was showing no codes and no check engine light.

The Internet of things says this hot stalling on a 2.2 is primarily caused by:
- Bad ignitor
- Cracked coil in the distributor
- Bad ECT Engine Coolant Temp Sensor

Chasing this problem and others, I had replaced all of those, and in addition
- Plugs
- Wires
- EGR valve
- EGR proportioning valve

What I found is my rough / low idle was caused by a dirty Idle Air Valve. I took this off and cleaned it with throttle body cleaner like is posted everywhere on the Internet.

After I took the ECU apart I found a blow 147pf capacitor, it had **** the bed. So using a capacitor replacement kit from Ebay "1990-2002 Toyota / Lexus ECU/ECM/Computer Capacitor Kit (MR2, Camry, LS400, etc)
Listed for charity.1990-2002 Toyota / Lexus ECU/ECM/Computer Capacitor Kit (MR2, Camry, LS400, etc)" from the seller "blenddoor" (no affiliation).

I replaced all of the capacitors in the ECU and that fixed it!! No more hot stall, car starts and idles like new, can restart when hot over and over with no issues.

Heres the ECU



And here's a shot of the capacitor that **** the bed. The top didn't bulge, instead it leaked out the bottom. The leakage is the brown pile underneath it.



Hope that helps somebody, it was a long journey for myself and even the dealer.
post Sep 14, 2020 - 10:10 AM
+Quote Post
presure2



Moderator
*****
Joined Oct 1, '02
From fall river, ma
Currently Offline

Reputation: 13 (100%)




good to hear!
for future refrence there is a company called relentless motorsports out of TX that can complete this service for people that dont feel comfortable replacing the caps themselves.


--------------------
Former Team 5SFTE pro member ;)

13.6@108MPH, 5SFTE Powered
post Sep 14, 2020 - 10:06 PM
+Quote Post
njccmd2002



Enthusiast
*****
Joined Mar 15, '07
From Tennessee
Currently Offline

Reputation: 52 (100%)




QUOTE (presure2 @ Sep 14, 2020 - 10:10 AM) *
good to hear!
for future refrence there is a company called relentless motorsports out of TX that can complete this service for people that dont feel comfortable replacing the caps themselves.


any ecu? I have a 1jz that sometimes has a hard start, and that has rough idle, not all the time, need to check that ecu


--------------------
Learned a lot in 10 years... I hardly log in anymore, last login Today Sept 6 2019, and I was forced just to clarify a post. LOL

If you PM me and I dont respond, dont fret or cry. Im alive, better post your questions in the thread below, maybe I log back in

2grfe Swapped... Why I chose the 2GR, before you ask read here...

A great civilization is not conquered from without until it has destroyed itself from within.


@llamaraxing in Instagram is the best way to find me. I hardly log here anymore.
post Sep 14, 2020 - 10:32 PM
+Quote Post
richee3



Moderator
*****
Joined Jun 29, '08
From Denver
Currently Online

Reputation: 59 (100%)




QUOTE (njccmd2002 @ Sep 14, 2020 - 9:06 PM) *
any ecu? I have a 1jz that sometimes has a hard start, and that has rough idle, not all the time, need to check that ecu

If they don’t, Drift Motion in St. Louis will do the 1JZ ECU for sure.


--------------------
"Employ your time in improving yourself by other men's writings, so that you shall gain easily what others labored hard for." -Socrates. Even Socrates told us to use the search button!

2006 Aston Martin V8 Vantage.
1998 Celica GT-
BEAMS Swapped.
2022 4Runner TRD Off Road Prenium.
2021 GMC Sierra AT4.
post Sep 14, 2020 - 10:36 PM
+Quote Post
njccmd2002



Enthusiast
*****
Joined Mar 15, '07
From Tennessee
Currently Offline

Reputation: 52 (100%)




QUOTE (richee3 @ Sep 14, 2020 - 10:32 PM) *
QUOTE (njccmd2002 @ Sep 14, 2020 - 9:06 PM) *
any ecu? I have a 1jz that sometimes has a hard start, and that has rough idle, not all the time, need to check that ecu

If they don’t, Drift Motion in St. Louis will do the 1JZ ECU for sure.



ill have to take it apart and examine. thx

This post has been edited by njccmd2002: Sep 14, 2020 - 10:36 PM


--------------------
Learned a lot in 10 years... I hardly log in anymore, last login Today Sept 6 2019, and I was forced just to clarify a post. LOL

If you PM me and I dont respond, dont fret or cry. Im alive, better post your questions in the thread below, maybe I log back in

2grfe Swapped... Why I chose the 2GR, before you ask read here...

A great civilization is not conquered from without until it has destroyed itself from within.


@llamaraxing in Instagram is the best way to find me. I hardly log here anymore.
post Sep 14, 2020 - 11:18 PM
+Quote Post
Bitter

Enthusiast
*****
Joined Mar 11, '06
From Way South Chicago
Currently Offline

Reputation: 0 (0%)




This has cropped up with a problem Corolla over at Toyotanation as well that had an intermittent no start and odd engine light operation. It's been a known issue with gauge clusters failing on 7th gen Corolla for a number of years, but I guess the ECU's are aging into this as well. It's a problem best caught early, the chemical slurry inside the caps can eat board traces which is a big problem potentially. You have to be pretty handy to fix that level of broken.


--------------------
post Sep 15, 2020 - 7:00 AM
+Quote Post
navseal345



Enthusiast
****
Joined Aug 17, '09
From Millard, Omaha, Nebraska
Currently Offline

Reputation: 1 (100%)




Now this is a good/ interesting post. Thanks for sharing.
post Sep 15, 2020 - 12:47 PM
+Quote Post
njccmd2002



Enthusiast
*****
Joined Mar 15, '07
From Tennessee
Currently Offline

Reputation: 52 (100%)




holly moly its 700+ dollars at drift motion

https://www.driftmotion.com/1JZ-ECU-Cap-Service-p/dm1251.htm


--------------------
Learned a lot in 10 years... I hardly log in anymore, last login Today Sept 6 2019, and I was forced just to clarify a post. LOL

If you PM me and I dont respond, dont fret or cry. Im alive, better post your questions in the thread below, maybe I log back in

2grfe Swapped... Why I chose the 2GR, before you ask read here...

A great civilization is not conquered from without until it has destroyed itself from within.


@llamaraxing in Instagram is the best way to find me. I hardly log here anymore.
post Sep 15, 2020 - 1:04 PM
+Quote Post
njccmd2002



Enthusiast
*****
Joined Mar 15, '07
From Tennessee
Currently Offline

Reputation: 52 (100%)




im going to call this guy

https://www.youtube.com/watch?v=VC4f6XlEyMA


--------------------
Learned a lot in 10 years... I hardly log in anymore, last login Today Sept 6 2019, and I was forced just to clarify a post. LOL

If you PM me and I dont respond, dont fret or cry. Im alive, better post your questions in the thread below, maybe I log back in

2grfe Swapped... Why I chose the 2GR, before you ask read here...

A great civilization is not conquered from without until it has destroyed itself from within.


@llamaraxing in Instagram is the best way to find me. I hardly log here anymore.
post Sep 17, 2020 - 6:38 AM
+Quote Post
presure2



Moderator
*****
Joined Oct 1, '02
From fall river, ma
Currently Offline

Reputation: 13 (100%)




QUOTE (njccmd2002 @ Sep 14, 2020 - 11:06 PM) *
QUOTE (presure2 @ Sep 14, 2020 - 10:10 AM) *
good to hear!
for future refrence there is a company called relentless motorsports out of TX that can complete this service for people that dont feel comfortable replacing the caps themselves.


any ecu? I have a 1jz that sometimes has a hard start, and that has rough idle, not all the time, need to check that ecu

yes.


--------------------
Former Team 5SFTE pro member ;)

13.6@108MPH, 5SFTE Powered

Reply to this topicStart new topic
1 User(s) are reading this topic (1 Guests and 0 Anonymous Users)
0 Members:

 



Lo-Fi Version Time is now: March 28th, 2024 - 6:38 AM