Climate control wiring Options

[Cavegod]

Hi all i am curently installing cauto climate control in to a non climate control car so thats climate control out of a 1994 jdm Gen6 Celica st202 and installing it into a 1997 uk Gen6 gt st202.

does anybody know where to get a wiring diagram for the auto climate control system as i can only find one for a Gen5 st182 celica.

heres hoping

Pete

[Rusty]

Cheers Rusty, you will need to remove the trim around gearstick (just unclips at the back then the front, the trim around heater and stereo 2 screws at the bottom then just pull from bottom, remove the heater controls 2 screws and unclip the plugs at the back.

the wires i need to know about are as follows.

behind the heater control and lower down are three multiplugs attached to the heater box from left to right they are Black, white, grey. may be opposite if left hand drive.

on the black plug on the bottom row there is an orange wire i need to make sure this has continuity to the orange wires on the blue plug above and to the right(RHD) of the centre vents.

on the middle white plug i need to know if the green/red wire bottom row next to a grey wire has 12v with ignition off and also the grey wire next to it has 12v with ignition on and 0v with ignition off.

many thanks if you do this for me.

right first off sorry for not getting back to you sooner, I had a look around, I tryed to followed the wires (which go up in one lot) and I cant see where they go
got a couple of pictures dont think they'll help you though, but from the looks of your previous post you might already have it.

(sorry the loose wires, USB wire & that funny looking black right angle thing are a plug and play for my headunit)




http://www.toyodiy.com/parts/p_J_1996_TOYO...MVF_8715.4.html
just wondering did you have to wire those up or are they not part of it?




I also found the bulb I need to replace for the fan speed (lower left bulb) I went on toyodiy 84999-10530 that seem right to you guys?

This post has been edited by Rusty: Aug 14, 2009 - 8:12 PM

[BloodyStupidDave...]

from the looks of your previous post you might already have it.

Yes I was under that impression also. Please let me know if you need any further diagnositcs or wires tracing. I have the centre console and glove box removed at the moment so would be very easy for me to do.